Product ID:ALODINE 1202 THIXOTROPIC POWDER
MSDS Date:05/19/1989
FSC:8030
NIIN:01-069-3030
MSDS Number: BJXQV

HENKEL CORPORATION

32100 STEPHENSON HIGHWAY
MADISON HEIGHTS, MI 48071
US

Emergency Phone: 517-263-9430

Info Phone: 313-583-9300

Cage: DO342

PARKER-ACHEM

UNKNOW CINCINNATI, OH 45232 US

Telephone: 513-482-2297

Cage: NO775

CHROMIUM (SARA III)

CAS: 7440-47-3

RTECS: GB4200000

Fraction By Weight: 10-30%

OSHA PEL 1 MG/M3

ACGIH TLV: 0.5 MG/M3; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SODIUM FLUORIDE (SARA III)

CAS: 7681-49-4

RTECS: WB0350000

Fraction By Weight: 1-10%

OSHA PEL 2.5 PPM F

ACGIH TLV: 2.5 MG F/M3; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

POTASSIUM FERROCYANIDE (SARA 313)

CAS: 13746-66-2

RTECS: LJ8225000

Fraction By Weight: 1-10%

POTASSIUM FLUROBORATE

CAS: 14075-53-7

RTECS: ED2800000

Fraction By Weight: 1-10%

OSHA PEL 2.5 MG/M3 (AS F)

ACGIH TLV: 2.5 MG/M3 (AS F)

LD50 LC50 Mixture:LD50 (ORAL-RAT):51.10 +/- 5.93 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:MAY CAUSE CHROME SORES, LIVER DAMAGE,
KIDNEY DAMAGE AND DERMATITIS. MAY CAUSE ULCERATION AND PERFORATION
OF THE NASAL SEPTUM. CONTAINS FLUORIDES, EXPOSURE TO FLUORIDES OVER
YEARS MAY CAUSE FLUOROSIS.
Explanation of Carcinogenicity:THERE IS SUFFICIENT EVIDENCE FOR THE
CARCINOGENICITY OF CHROMIUM & CERTAIN CHROMIUM CPD BOTH IN HUMANS &
EXPER ANIMALS.
Effects of Overexposure:EYES:BURNS,LOSS OF VISION.SKIN:BURNS.FATAL
KIDNEY DAMAGE.INGESTION:GASTROINTESTINAL DAMAGE;BURNS OF THE
DIGESTIVE TRACT.CHROMIC ACID IS CONSIDERED VERY
TOXIC.INHALATION:DAMAGE TO MUCOUS MEMBRANES,PERF ORATION OF NASAL
SEPTUM AND IRRITATION OF THE RESPIRATORY SYSTEM.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF ASTHMA,
ALLERGIES OR KNOWN SENSITIZATIONS TO CHROMIC ACID OR CHROMATES.

First Aid:EYES:FLUSH IN DIRECT STREAM OF H2O FOR 15 MIN WHILE HOLDING
EYELIDS APART.GET MED ATTN.SKIN:REMOVE CONTAM CLOTHES/ SHOES.FLUSH
W/H2O FOR 15 MIN.RINSE CLOTHES.IF IRRIT PERSISTS,GET MED ATTN.
INGESTED:D RINK LARGE AMTS OF H2O.CORROSIVE.DONOT INDUCE VOMIT.IF
VOMITING OCCURS,DRINK MORE H2O.GET MED ATTN.NEVER GIVE ANYTHING BY
MOUTH TO AN UNCON PERSON.INHALED:MOVE TO FRESH AIR.IF BREATH
DIFF,GIVE OXYGEN.

Flash Point:NONE
Extinguishing Media:WATER
Fire Fighting Procedures:WEAR POSITIVE PRESSURE SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VIOLENT REACTIONS MAY OCCUR WITH ORGANIC
MATERIALS OR REDUCING AGENTS.

Spill Release Procedures:WEAR PROTECTIVE CLOTHING. SWEEP UP OR
OTHERWISE COLLECT AND STORE IN SUITABLE DRUM.

Handling and Storage Precautions:DO NOT TAKE INTERNALLY. WASH
THOROUGHLY AFTER HANDLING. DO NOT GET IN EYES, ON
SKIN/CLOTHING.CONTACT W/COMBUST MAT'L MAY CAUSE FIRE.

Respiratory Protection:NIOSH APPROVED; AS REQUIRED TO MAINTAIN EXPOSURE
BELOW TLV'S/PEL'S
Ventilation:LOCAL EXHAUST
Protective Gloves:NEOPRENE OR POLYVINYL GLOVES.
Eye Protection:CHEMICAL GOGGLES OR FACE SHIELD.
Other Protective Equipment:APPROPRIATE PROTECTIVE CLOTHING, EYE WASH
FACILITY AND EMERGENCY SHOWER SHOULD BE IN CLOSE PROXIMITY.
Supplemental Safety and Health
POSS CANCER HAZARD:THERE IS LAB EVIDENCE THAT AQUEOUS SODIUM DICHROMATE
ADMINIST DIRECT INTO LUNGS,AT THE HIGHEST TOLERATED DOSE,OVER THE
LIFETIME OF RATS,CAUSES A SIGNIFICANTLY INCREASED INCIDENCE OF
LUNG CANCER.IT IS EXPECTED THAT IF CHROMIC ACID WAS TESTED IN THE
MANNER AS AQUEOUS SODIUM WOULD GIVE SIMILIAR RESPONSE

HCC:T6
Solubility in Water:APPRECIABLE
Appearance and Odor:ORANGE POWDER,BLAND ODOR

Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, REDUCING AGENTS, ALKALINE MATERIALS.
Hazardous Decomposition Products:HYDROGEN CYANIDE AND HYDROGEN
FLUORIDE.
Conditions to Avoid Polymerization:EXCESSIVE HEAT

Waste Disposal Methods:DISPOSE OF IN COMPLIANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.THIS CHEMICAL IS A HAZARDOUS
WASTE DEFINED BY EPA.WASTE TREATMENT AND NEUTRALIZATION MAY BE
REQUIRED PRIOR TO DISCHARG E TO A SEWER.CONTACT A LICENSED DISPOSAL
AGENT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.